Product ID:347-931,INORGANIC ZINC COATING
MSDS Date:01/01/1985
FSC:8010
NIIN:00-145-0184
Kit Part:Y
MSDS Number: BDCDR

E.I. DUPONT DE NEMOURS & CO,INC

Emergency Phone: 302-774-2421

Cage: 19898

E.I. DUPONT DE NEMOURS & CO., INC.

1635 WILMINGTON, DE 19898 US

Telephone: 800-441-7515;800-441-9442

Cage: 19898

ZINC (SARA III)

CAS: 7440-66-6

RTECS: ZG8600000

Fraction By Weight: 87%

OSHA PEL 10 MG ZNO/M3

ACGIH TLV: 10 MG ZNO/M3; 9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SOLIDS,HAZARD UNKNOWN,UNIDENTIFIED

Fraction By Weight: 13%

Effects of Overexposure:HEADACHE,NAUSEA,IMPAIRMENT OF REACTION TIME AND
COORDINATION.

First Aid:REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEED. SKIN:WASH WITH
SOAP & WATER. EYES:FLUSH WITH WATER 15 MIN. KEEP WARM AND QUIET
!

Flash Point:20-80F TOC
Lower Limits:1.27
Upper Limits:12.0
Extinguishing Media:CO*2, FOAM, DRY CHEM.
Fire Fighting Procedures:USE H*20 TO COOL EXPD CONTRS. USE SCBA & FULL
PROT.CLTHG.
Unusual Fire/Explosion Hazard:NONE NOTED BY MANUFACTURER.

Spill Release Procedures:REMOVE IGNITION SOURCES,VENTILATE AREA
WELL.ABSORB WITH VERMICULITE OR OTHER MATERIALS, SUCH AS
SAWDUST,RAGS,PAPER & PLACE IN CLOSED CONTAINER. USE NON SPARKING
TOOLS. WEAR PROPER PROTECTIVE EQUIPMENT DURING CLEAN UP.

Handling and Storage Precautions:KEEP AWAY FROM IGNITION SOURCES.KEEP
CONTAINERS CLOSED.DO NOT STORE ABOVE 120F.AVOID PHYSICAL DAMAGE.
Other Precautions:WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
SMOKING.OBSERVE LABEL PRECAUTIONS.CONTAINERS SHOULD BE GROUNDED
WHEN POURING.

Respiratory Protection:USE ADEQUAT VENT.CARTRIDG-TYPE RESPIR IF MECH
CONTROLS NOT FEASIBLE.
Ventilation:LOCAL EXHAUST TO MAINTN BELOW TLV AND LEL.
Protective Gloves:IMPERVIOUS
Eye Protection:CHEM SPLASH GOGGLES
Other Protective Equipment:USE APPROPIATE HYGIENE PRACTICES.
Supplemental Safety and Health
NO SPECIFIC MSDS FOR ZINC.SAFETY INFO FOR KIT.

HCC:F2
Boiling Pt:B.P. Text:176-347F
Vapor Pres:37
Vapor Density:3.14
Spec Gravity:2.59
Evaporation Rate & Reference:<1(ETHER=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:SEMI-VISCOUS GREEN LIQUID(MIXED) ;SWEET ODOR.
Percent Volatiles by Volume:58.5

Stability Indicator/Materials to Avoid:YES
DO NOT MIX WITH PRODUCTS CONTAINING WATER;WILL GEL.
Stability Condition to Avoid:AVOID MOISTURE IN CAN;MIX A & B PRIOR TO
USING.
Hazardous Decomposition Products:CO,CO*2,SMOKE,OXIDES OF ZINC.

Waste Disposal Methods:KEEP IN COVERED DRUMS,PENDING DISPOSAL. HANDLE &
DISPOSE IN FULL COMPLIANCE WITH ALL APPLICABLE
INTERNATIONAL,FEDERAL,STATE, & LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.